全自動涼茬機可全自動放水、下曲、進料、拌和勻稱、散冷實際效果以及理想化。下面為大家介紹一下全自動涼茬機的使用后應該怎樣維護。
The full-automatic stubble cooler can automatically discharge water, bend, feed, mix evenly, disperse the actual effect of cooling and idealize. Here is how to maintain the automatic stubble cooler after use.
全自動涼茬機是一種新型制酒設備，具有更快，效率高特點。注意鍋爐在燒火過程一定要打開鍋爐上方的蒸汽閥門每臺涼茬機經常出現接曲裝置組成。接曲裝置位于涼茬機的底部，造成對開料口溢料的收集作用，從而節約原料，避免出現消耗的情況。
The automatic stubble cooler is a new type of wine making equipment, which has the characteristics of faster and higher efficiency. Note that the steam valve above the boiler must be opened during the firing process of the boiler. Each stubble cooler is often composed of a bending device. The bending device is located at the bottom of the stubble cooler to collect the overflow material at the opening, thus saving raw materials and avoiding consumption.
此外全自動涼茬機裝有多個軸流風機，通過風量的調節，使高溫涼茬在輸送過程中降到規定的溫度，攤晾效果好，在攤晾過程中設置多個攪拌裝置，使涼茬在攤晾過程中松散、不易結坨，加漿、下曲均勻，數量可調節，通過裝置可將漿水、曲粉、糧茬攪拌均勻。
In addition, the full-automatic stubble cooler is equipped with a plurality of axial flow fans. Through the adjustment of air volume, the high-temperature stubble can be reduced to the specified temperature during the conveying process, and the spreading and drying effect is good. During the spreading and drying process, a plurality of mixing devices are set to make the stubble loose and not easy to form lumps, and the amount of pulp and down warping can be adjusted. Through the device, the slurry, yeast powder and grain stubble can be mixed evenly.
安裝前需要挖坑、砌墻、安排污管道等繁瑣的準備工作。使用全自動涼茬機，涼茬網帶漏掉的茬子直接落入本機設計的不銹鋼箱體內，清理后完全臥池利用，清理簡便杜絕了浪費與污染環境現象。安裝前，車間地面不需任何準備工作。還可根據需要，移動使用。
Before installation, it is necessary to excavate pits, build walls, arrange sewage pipes and other cumbersome preparations. The full-automatic stubble cooler is used. The stubble leaked from the stubble net belt directly falls into the stainless steel box designed by the machine. After cleaning, it is completely used in the pool. It is easy to clean and eliminates waste and environmental pollution. Before installation, the workshop floor does not need any preparation. It can also be used as needed.
1、班次作業后的維護：全自動涼茬機每班作業完成后，要清理干凈全自動涼茬機上的殘存殘存的材料，避免設備生銹，然后翻開機罩，把各個部件上纏繞的雜草摘除。
1. Maintenance after shift operation: after the operation of the full-automatic stubble cooler is completed, the residual materials on the full-automatic stubble cooler shall be cleaned to avoid rusting of the equipment, and then the cover shall be opened to remove the weeds wrapped on each part.
2、運用一周后的維護：由于小型
全自動涼茬機運用一周后要對萬向節、軸承等加注黃油，并對其他光滑點停止檢查和補充。檢查設備皮帶的磨損狀況，假如磨損嚴重，要及時改換。
2. Maintenance after one week of operation: since the small full-automatic stubble cooler is used for one week, it is necessary to add grease to the universal joint and bearing, and stop checking and supplementing other smooth points. Check the wear condition of the equipment belt. If the wear is serious, replace it in time.
3、每季作業后的維護：在每季作業全部完成后，不只要把全自動涼茬機全部清算潔凈，還要將三角帶放松。各運轉部位的軸承檢查改換后，加足黃油。
3. Maintenance after operation in each season: after the operation in each season is completed, not only the automatic stubble cooler is cleared, but also the triangle belt is loosened. After inspection and replacement of bearings at all operating parts, add enough grease.
全自動涼茬機工作時，水密封槽忽然參加很多冷水，形成負壓。方案漸漸的往密封槽內參加冷水，想減少加密封槽水的時刻，可參加與現有密封槽差不多溫度的熱水。更多相關事項就來我們網站
http://www.justeve.cn咨詢。
When the full-automatic stubble cooler works, the water seal groove suddenly participates in a lot of cold water, forming a negative pressure. The solution is to gradually add cold water into the sealing tank. If you want to reduce the time of encrypting the water in the sealing tank, you can participate in hot water at the same temperature as the existing sealing tank. For more information, please visit our website http://www.justeve.cn consulting service
自動售酒機 2024-07-25 
